Hyundai Elantra MD/UD: Troubleshooting
Troubleshooting
|
Symptom |
Suspect Area |
Remedy (Refer to page) |
|
Water leaks from sunroof |
Dirt accumulated in drain tube |
Clear dirt inside of drain |
|
Clogged drain tube |
Blow air into drain to remove dirt |
|
|
Broken or dislocated drain tube, defective or cracked clip |
Check tube installation and flange contact |
|
|
Deteriorated roof lid weatherstrip |
Replace |
|
|
Excessive roof lid-to-body clearance and improperly fitted weatherstrip |
Adjust |
|
|
Wind noise around sunroof |
Loosen or deformed deflector, gaps in body work |
Retighten adjust or replace |
|
Sunroof lid makes a noise when move |
Foreign particles lodged in guide rail |
Check drive cable and guide rails for foreign particles |
|
Loosen guide rails and lid |
Retighten |
|
|
Motor runs but sunroof does not move or moves only partially |
Foreign particles lodged in guide rail |
Adjust or replace |
|
Incorrect engagement of motor pinion with drive cable |
||
|
Decrease in motor`s clutch slipping force |
||
|
Increased sunroof sliding resistance or interference of sunroof with
drive cables, weatherstrip, etc. due tomal adjustment of sunroof |
||
|
Noise in motor (clutch slipping noise from motor when sunroof is fully
opened or closed is not an unusual noise |
Incorrect engagement of motor pinion with drive cable |
Check pinion installation and Re-tighten motor |
|
Worn out or damaged motor pinion bearing |
Replace motor assembly |
|
|
Worn out or deformed drive cable |
Replace |
|
|
Door glass fails to operate up and down |
Incorrect window glass installation |
Adjust position |
|
Damaged or faulty regulator arm or regulator |
Correct or replace |
|
|
Door does not open or close completely |
Incorrect door installation |
Adjust position |
|
Defective door check assembly |
Correct or replace |
|
|
Door hinge requires grease |
Apply grease |
|
|
Hood does not open or close completely |
Striker and latch not properly aligned |
Adjust |
|
Incorrectly installed hood |
Adjust |
|
|
Incorrect hood bumper height |
Adjust |
|
|
Water leak through windshield end rear window |
Defective seal |
Fill with sealant |
|
Defective flange |
Correct |
